FREE ENGLISH OKLAHOMA JOE’S BRONCO 19202089 (01) PDF USER GUIDE
FREE ENGLISH OKLAHOMA JOE’S BRONCO 19202089 (01) PDF USER MANUAL
FREE ENGLISH OKLAHOMA JOE’S BRONCO 19202089 (01) PDF OWNER GUIDE
FREE ENGLISH OKLAHOMA JOE’S BRONCO 19202089 (01) PDF OWNER MANUAL
FREE ENGLISH OKLAHOMA JOE’S BRONCO 19202089 (01) PDF REFERENCE GUIDE
FREE ENGLISH OKLAHOMA JOE’S BRONCO 19202089 (01) PDF INSTRUCTION GUIDE
FREE ENGLISH OKLAHOMA JOE’S BRONCO 19202089 (01) PDF REFERENCE MANUAL
FREE ENGLISH OKLAHOMA JOE’S BRONCO 19202089 (01) PDF INSTRUCTION MANUAL
FREE ENGLISH OKLAHOMA JOE’S BRONCO 19202089 (01) PDF OPERATING INSTRUCTIONS
CLICK HERE TO DOWNLOAD OKLAHOMA JOE’S BRONCO 19202089 (01) PDF MANUAL
If this is not the document you want for this product, click here to see if we have any other documents for this product.
OKLAHOMA JOE’S BRONCO 19202089 (01) PDF SUMMARY:
How do I assemble the grill?
Assemble your grill on a level, protective surface to prevent damage to the unit. The outer carton is ideal for this purpose. Place the carton top side up. Cut all 4 corners with a utility knife and allow the carton panels to lay flat, as shown in the PDF.
What should I do before tightening the screws and washers?
Loosely install first screw and washer. DO NOT tighten. Loosely install remaining screws and washers. When items #3 & #5 are aligned, tighten all screws.
How should I align the notch?
Align notch as shown in the PDF.
Should I fully tighten the wheel brackets?
NOTE: Do not fully tighten wheel brackets 26 &27.
What is the next step after installing the wheel brackets?
Fully tighten wheel brackets from step 3.
What should I do while holding the Temperature Gauge?
While holding the Temperature Gauge in desired position, use this nut to tighten the Temperature Gauge. DO NOT use the face of the temperature gauge to tighten.
What is included in the hardware list?
Here is the hardware list:
| KEY / CLV / CLE | DESCRIPTION / DESCRIPCIÓN | IMAGE | QTY/QTE / CANT |
|---|---|---|---|
| A | 1/4-20×5/8" Hex Bolt 1/4-20×5/8" Boulon hexagonal 1/4-20×5/8" Perno hexagonal | 38 | |
| B | 1/4-20 Hex Nut 1/4-20 Écrou hexagonal 1/4-20 Tuerca hexagonal | 15 | |
| C | 1/4 Flat Washer 1/4 Rondelle plate 1/4 Lavadora plana | 4 | |
| D | M12 Flat Washer M12 Rondelle plate M12 Lavadora plana | 1 | |
| E | 1.5" Hitch Pin 1.5" Broche d’attelage 1.5" Pin De Conector | 1 | |
| F | 1/4 Flat Washer 1/4 Rondelle plate 1/4 Lavadora plana | 6 |
What are the tools needed for assembly?
Adjustable Wrench, Phillips Screwdriver (Tools not provided)
What is covered under the limited warranty?
The limited warranty covers perforation, manufacturing, and material defects only.
What is the period of coverage for all parts under the limited warranty?
The coverage period is 2 years from the date of purchase. A dated sales receipt WILL be required for warranty service.
Who is responsible for shipping charges for parts replaced under the limited warranty?
The original consumer-purchaser will be responsible for all shipping charges for parts replaced under the terms of this limited warranty.
Is the limited warranty transferable?
No, this limited warranty is applicable in the United States and Canada only, is only available to the original owner of the product and is not transferable.
What does the manufacturer require for proof of purchase?
Manufacturer requires proof of your date of purchase. Therefore, you should retain your sales slip or invoice. Registering your product is not a substitute for proof of purchase and the manufacturer is not responsible for or required to retain proof of purchase records.
What does the limited warranty apply to?
This limited warranty applies to the functionality of the product ONLY and does not cover cosmetic issues such as scratches, dents, corrosions or discoloring by heat, abrasive and chemical cleaners or any tools used in the assembly or installation of the appliance, surface rust, or the discoloration of stainless steel surfaces. Paint is not warranted and will require touch up. RUST is not considered a manufacturing or materials defect.
Will the limited warranty reimburse for any inconvenience, food, personal injury, or property damage?
No, This limited warranty will not reimburse you for the cost of any inconvenience, food, personal injury or property damage.
What items will the manufacturer not pay for?
The manufacturer will not pay for:
- Shipping cost, standard or expedited, for warranty and replacement parts
- Service calls to your home.
- Repairs when your product is used for other than normal, single-family household or residential use.
- Damage, failures, or operating difficulties resulting from accident, alteration, careless handling, misuse, abuse, fire, flood, acts of God, improper installation or maintenance, installation not in accordance with electrical or plumbing codes, or use of products not approved by the manufacturer.
- Any food loss due to product failures or operating difficulties.
- Replacement parts or repair labor costs for units operated outside the United States or Canada.
- Pickup and delivery of your product.
- Repairs to parts or systems resulting from unauthorized modifications made to the product.
- The removal and/or reinstallation of your product.
What is the exclusive remedy under the limited warranty?
Repair or replacement of defective parts is your exclusive remedy under the terms of this limited warranty. In the event of parts availability issues, the manufacturer reserves the right to substitute like or similar parts that are equally functional.
What will the manufacturer not be responsible for?
Manufacturer will not be responsible for any consequential or incidental damages arising from the breach of either this limited warranty or any applicable implied warranty, or for failure or damage resulting from acts of God, improper care and maintenance, grease fire, accident, alteration, replacement of parts by anyone other than Manufacturer, misuse, transportation, commercial use, abuse, hostile environments (inclement weather, acts of nature, animal tampering), improper installation or installation not in accordance with local codes or printed manufacturer instructions.
What is the sole express warranty given by the manufacturer?
THIS LIMITED WARRANTY IS THE SOLE EXPRESS WARRANTY GIVEN BY THE MANUFACTURER. NO PRODUCT PERFORMANCE SPECIFICATION OR DESCRIPTION WHEREVER APPEARING IS WARRANTED BY MANUFACTURER EXCEPT TO THE EXTENT SET FORTH IN THIS LIMITED WARRANTY. ANY IMPLIED WARRANTY PROTECTION ARISING UNDER THE LAWS OF ANY STATE, INCLUDING IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR USE, IS HEREBY LIMITED IN DURATION TO THE DURATION OF THIS LIMITED WARRANTY.
Do dealers or retail establishments have the authority to make additional warranties?
Neither dealers nor the retail establishment selling this product has any authority to make any additional warranties or to promise remedies in addition to or inconsistent with those stated above. Manufacturer’s maximum liability, in any event, shall not exceed the purchase price of the product paid by the original consumer.
What should I do if I wish to obtain performance of any obligation under this limited warranty?
If you wish to obtain performance of any obligation under this limited warranty, you should write to:
Consumer Relations
P. O. Box 1240
Columbus, GA 31902-1240
What are the requirements for consumer returns?
Consumer returns will not be accepted unless a valid Return Authorization is first acquired. Authorized returns are clearly marked on the outside of the package with an RA number and the package is shipped freight/postage pre-paid. Consumer returns that do not meet these standards will be refused.
What is the carbon monoxide hazard associated with burning charcoal?
Burning charcoal inside can kill you. It gives off carbon monoxide, which has no odor. NEVER burn charcoal inside homes, vehicles, or tents.
What could result from failure to follow manufacturer’s instructions?
Failure to follow all manufacturer’s instructions could result in serious personal injury and/or property damage.
What is the importance of the ash catcher pan?
Ash catcher pan must be fully installed during operation. Failure to properly install could result in hot embers falling from grill.
What precaution should be taken due to hot surfaces?
Most surfaces on this unit are hot when in use. Use extreme caution. Keep others away from unit. Always wear protective clothing to prevent injury.
Is it safe to move the unit during operation?
Do not move this unit during operation.
Where should children and pets be when the unit is in use?
Keep children and pets away.
What should never be used as a substitute for charcoal starter?
Never substitute gasoline, kerosene or alcohol for charcoal starter. In some states, the use of charcoal starter is prohibited by law. In this case, paraffin-based starter cubes can be substituted for charcoal starter.
Can charcoal starter fluid be used with an electric starter?
Never use charcoal starter fluid with an electric starter.
What protection is required to prevent burning?
All surfaces can be hot during use. Use protection as required to prevent burning.
Where should the unit not be used?
Do not use this unit on or near combustible surfaces or structures such as wood decks, dry leaves or grass, vinyl or wood siding, etc.
What could result from failure to read and follow instructions for lighting charcoal?
FAILURE TO READ AND FOLLOW INSTRUCTIONS FOR LIGHTING CHARCOAL MAY RESULT IN SERIOUS PERSONAL INJURY AND OR PROPERTY DAMAGE.
What should always be used when handling hot coals?
ALWAYS USE CAUTION WHEN HANDLING HOT COALS TO PREVENT INJURY.
How should the fire be lit?
ALWAYS LIGHT THE FIRE WITH THE GRILL LID OPEN.
What can happen with unconsumed embers?
After a charcoal fire appears extinguished, unconsumed embers can retain heat for up to 24 hours, and if exposed to fresh air, can burst into flame unexpectedly. Any such embers outside the firebox of the grill pose a fire hazard and can ignite combustible surfaces such as wooden decks.
How far should the grill be from walls or surfaces?
Use grill at least 3 ft. from any wall or surface. Maintain 10 ft. clearance to objects that can catch fire or sources of ignition such as pilot lights on water heaters, live electrical appliances, etc.
Where should the grill be used?
Use grill only in well-ventilated space. NEVER use in enclosed space such as carport, garage, porch, covered patio, or under an overhead structure of any kind.
What safety measures should be followed before assembly and cooking?
Read and follow all safety statements, assembly instructions, and use and care directions before attempting to assemble and cook.
Is the unit for residential or commercial use?
For residential use only. Do not use for commercial cooking.
What precautions should be taken regarding sharp edges?
Some parts may contain sharp edges! Wear protective gloves if necessary.
Is assistance needed for assembly?
THIS UNIT IS HEAVY! DO NOT attempt to assemble without a helper.
Where should the unit be assembled?
This unit should be assembled on a level, stable surface.
Where should the unit be placed when cooking?
When cooking, the unit must be on a level, stable surface in an area clear of combustible material.
What are the parts included in the parts list?
Here is the Parts list:
| Key | Qty | Description |
|---|---|---|
| 1 | 1 | LID |
| 1A | 1 | GASKET F/LID |
| 2 | 1 | KIT, HINGE F/LID |
| 3 | 1 | UPPER BARREL BODY |
| 4 | 1 | KIT, LOGO PLATE |
| 5 | 1 | LOWER BARREL BODY |
| 6 | 1 | KIT, HANDLE F/LID |
| 7 | 9 | FOOD HOOK |
| 8 | 3 | FOOD HANGER |
| 9 | 1 | LIFT OUT TOOL |
| 10 | 1 | SMOKE STACK ASSEMBLY |
| 11 | 1 | TEMPERATURE GAUGE |
| 12 | 3 | GRATE SUPPORT |
| 13 | 1 | COOKING GRATE |
| 14 | 1 | SIDE HANDLE |
| 15 | 1 | SHELF ASSEMBLY |
| 16 | 1 | CHARCOAL BASKET |
| 17 | 1 | CHARCOAL GRATE |
| 18 | 1 | ASH PAN ASSEMBLY |
| 19 | 1 | ASH PAN SUPPORT |
| 20 | 2 | LEG |
| 21 | 1 | AXLE |
| 22 | 1 | AIR INTAKE CHANNEL, LOWER ASSEMBLY |
| 23 | 1 | AIR INTAKE CAP |
| 24 | 1 | AIR INTAKE CHANNEL, UPPER ASSEMBLY |
| 25 | 1 | AIR INTAKE DAMPER |
| 26 | 1 | WHEEL BRACKET, REAR |
| 27 | 1 | WHEEL BRACKET, FRONT |
| 28 | 2 | WHEEL |
| 29 | 1 | SMOKE STACK DAMPER |
| 30 | 2 | DAMPER SPRING |
| 31 | 2 | DAMPER CAP NUT |
| 32 | 1 | HEAT DEFLECTOR |
| … | 1 | HARDWARE PACK |
| … | 1 | PRODUCT GUIDE. ENGLISH, FRENCH, SPANISH |
What are the parts included in the Lista de piezas?
Here is the Parts list in Spanish:
| Llv | Cant | Descripción |
|---|---|---|
| 1 | 1 | TAPA |
| 1A | 1 | JUNTA, PARA TAPA |
| 2 | 1 | KIT, BISAGRA para TAPA |
| 3 | 1 | CUERPO SUPERIOR DEL BARRIL |
| 4 | 1 | KIT, PLACA DE LOGOTIPO |
| 5 | 1 | CUERPO DEL BARRIL INFERIOR |
| 6 | 1 | KIT, MANIJA DE LA TAPA |
| 7 | 9 | GANCHO DE COMIDA |
| 8 | 3 | PERCHA DE ALIMENTOS |
| 9 | 1 | LEVANTAR HERRAMIENTA |
| 10 | 1 | CONJUNTO DE PILA DE HUMO |
| 11 | 1 | INDICADOR DE TEMPERATURA |
| 12 | 3 | SOPORTE DE REJAS |
| 13 | 1 | REJILLA DE COCINA |
| 14 | 1 | MANIJA LATERAL |
| 15 | 1 | CONJUNTO DE ESTANTE |
| 16 | 1 | CESTA DE CARBÓN |
| 17 | 1 | REJILLA DE CARBÓN |
| 18 | 1 | ASAMBLEA DE CENDRES |
| 19 | 1 | SUPPORT DE CENDRES |
| 20 | 2 | PIERNA |
| 21 | 1 | EJE |
| 22 | 1 | CANAL DE ADMISIÓN DE AIRE, ENSAMBLAJE INFERIOR |
| 23 | 1 | TOMA DE ADMISIÓN DE AIRE |
| 24 | 1 | CANAL DE ADMISIÓN DE AIRE, ENSAMBLE SUPERIOR |
| 25 | 1 | AMORTIGUADOR DE ADMISIÓN DE AIRE |
| 26 | 1 | SOPORTE DE RUEDA, TRASERO |
| 27 | 1 | SOPORTE DE RUEDA, DELANTERO |
| 28 | 2 | RUEDA |
| 29 | 1 | AMORTIGUADOR DE PILA DE HUMO |
| 30 | 2 | MUELLE DE AMORTIGUACIÓN |
| 31 | 2 | TUERCA DE LA TAPA DEL DAMPER |
| 32 | 1 | DEFLECTOR DE CALOR |
| … | 1 | PAQUETE DE HARDWARE |
| … | 1 | GUÍA DE PRODUCTO. INGLÉS, FRANCÉS, ESPAÑOL |
What are the parts included in the List des Pieces?
Here is the Parts list in French:
| Clé | Qte | Description |
|---|---|---|
| 1 | 1 | COUVERCLE |
| 1A | 1 | JOINT, POUR COUVERCLE |
| 2 | 1 | KIT, CHARNIÈRE F / COUVERCLE |
| 3 | 1 | CORPS DE BARIL SUPERIEUR |
| 4 | 1 | KIT, PLAQUE LOGO |
| 5 | 1 | CORPS DE BARIL INFÉRIEUR |
| 6 | 1 | KIT, POIGNÉE POUR COUVERCLE |
| 7 | 9 | CROCHET ALIMENTAIRE |
| 8 | 3 | CINTRE ALIMENTAIRE |
| 9 | 1 | OUTIL DE SORTIE |
| 10 | 1 | ASSEMBLAGE DE L’EMPILEMENT DE FUMÉE |
| 11 | 1 | INDICATEUR DE TEMPÉRATURE |
| 12 | 3 | SUPPORT DE GRILLE |
| 13 | 1 | GRILLE DE CUISSON |
| 14 | 1 | POIGNÉE LATÉRALE |
| 15 | 1 | ASSEMBLAGE D’ÉTAGÈRE |
| 16 | 1 | PANIER CHARBON |
| 17 | 1 | GRILLE DE CHARBON |
| 18 | 1 | ASSEMBLAGE DE CENDRES |
| 19 | 1 | SUPPORT DE CENDRES |
| 20 | 2 | JAMBE |
| 21 | 1 | ESSIEU |
| 22 | 1 | CANAL D’ADMISSION D’AIR, ENSEMBLE INFÉRIEUR |
| 23 | 1 | CAP D’ADMISSION D’AIR |
| 24 | 1 | CANAL D’ADMISSION D’AIR, ENSEMBLE SUPÉRIEUR |
| 25 | 1 | AMORTISSEUR D’ADMISSION D’AIR |
| 26 | 1 | SUPPORT DE ROUE, ARRIÈRE |
| 27 | 1 | SUPPORT DE ROUE AVANT |
| 28 | 2 | ROUE |
| 29 | 1 | AMORTISSEUR DE FUMÉE |
| 30 | 2 | AMORTISSEUR |
| 31 | 2 | ECROU DE CAPUCHON |
| 32 | 1 | DÉFLECTEUR DE CHALEUR |
| … | 1 | PACK MATÉRIEL |
| … | 1 | GUIDE DE PRODUIT ANGLAIS, FRANÇAIS, ESPAGNOL |
What does the warning indicate regarding combustion byproducts?
Combustion byproducts produced when using this product contain chemicals known to the State of California to cause cancer, and birth defects, or other reproductive harm.
What does the warning indicate regarding lead exposure?
This product can expose you to lead, which is known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to http://www.P65Warnings.ca.gov.
CLICK HERE TO DOWNLOAD OKLAHOMA JOE’S BRONCO 19202089 (01) PDF MANUAL