Post questions, comments, reviews or page errors in the comment box below.
PDF Content Summary:
****** Page 1 ****** INSTALLATION INSTRUCTIONS FOR THRUWALL ROOM TO ROOM FANTM SUNCOURT MODEL TW108 READ AND SAVE THESE INSTRUCTIONS IMPORTANT NOTICE US Step 3. Project the edge of the cutout onto the inside of the other wall board in three places, approximately 1200 apart. Use a small square or a piece of cardboard thot has an exact 900 angle to mark the cutout points on the inside of the other wall. The two circular must be accurately aligned. (Refer to picture 3) Step 4. Use a small sharp pin or very small drill bit (1/32″ or smaller) to punch or drill these three marks to the outside of the other wall. (Refer to picture 4) Step 5. Place the other sleeve, with grill attached, against the outside of the wall and center its location using the three markers that you hove made, thentraæ the outside of the sleeve with a pencil. Cutthe circular opening with a small drywall saw. Cut inside the pencil line. Take care not to damage the edge of the drywall. You will be installing drywall anchors dose to the hole to mount the grill. (Refer to picture 5) Step 6. Insert the metal sleeve with grill into the cutout opening (fan suction side) and snug the flange up against the wall material, making sure that power cord is hanging straight down. Step 7. Insert the other metal sleeve into the cutout opening (fan output side) and snug the flange UP against the wall material. Step 8. Position the unattached plastic grill over the metal sleeve that was iost inserted so that the Suncourt logo is at the bottom and that one of the mounting holes is in the top center. Mark the location of all 3 wall anchors. Make sure that the grill ribs are nicely square with the floor. Step 9. Mark the position for the wall anchors on the grill. Step 10. Remove metal sleeve with grill attached and drill the holes on both sides of the wall for the anchors with a WARNING – To Reduce The Risk Of Fire Or Electric Shock, Do Not Use This Fan With A Solid-Stote Speed Control Device. With the use of any electrical appliance, it is important to observe 011 basic precautions to minimize the risk associated with use, such as electrical shock, fire, or injury to persons. Read these instructions before using your ThruWoll Room to Room Fan If YOU have doubts or are unfamiliar with this type of installation work, seek the services of a qualified electrician. Suncourt assumes no responsibility for installation of the ThruWall Fan TN. Do not use a variable speed control with this product. Suncourt does not provide electrical connection information. For your safety and protection follow all instructions and adhere to applicable building and/or electrical codes. Not for bathroom use. Do not use in wet locations. Do not use in a window. Route the electric cord so that it cannot be tripped over. Use only a grounded wall outlet. WARNING – To Reduce The Risk Of Fire, Electric Shock Or Injury To Persons, Observe The Following: l. Installation work ond electrical wiring must be done by qualified person (s) in accordance with oll applicable codes and standards, including fire-rated construction. 2. When cutting or drilling into wall or ceiling, do not damage electrical wiring or other hidden Utilities, Operation Instructions: The ThruWaIITM is equipped with a two speed motor. There is a three position switch on the output side of the fan. The switches: position I is low speed, center (O) off, and position II is high speed. Thank you for buying this Suncourt product. The ThruWoII fan moves air from room to room quietly and efficiently. Simple to install in any frame wall from 3-3/4″ to 6-1/2″ thick. A high quality Thermally Protected motor with balanced fon blade moves up to 200 CFM. Move heated or cooled air between rooms. Excellent for ventilation! PLEASE READ THESE INSTRUCTIONS BEFORE STARTING INSTALLATION The ThruWoIIT” can be mounted in ony normal drywall or paneled stud construction wall UP to 6-1/2″ maximum total thickness. Depending on your needs, the ThruWoIITM con be installed high or low on the wall. Please note that worm air rises, thus is found neor the ceiling. Conversely, cold air falls and is found neor the floor. The temperature of the air near the ceiling may be os much os 100Fto 150F higher thon neor the floor. Stort by making sure that there are NO studs, water, drain, electrical or other obstruction in the woll where you wish to install the unit. The power cord of the ThruWoIITM is 10ft long, please verify thot the power cord will reach 0 110 Volt ACoutIet. The use of extension cords is not recommended. Please see the airflow direction lobel on the housing. The grills of your ThruWaII fan may be pointed to suit any decor. Thoroughly wash the grilles with mild household detergent, dry completely, ond spray with o quality, fost dry, spray point. The installation of your ThruWaII fan is not difficult, but the WtOUtS must be accurate. In the carton you will find: Telescoping metal sleeve with plastic grill attached. 1 Telescoping metol sleeve without grill attached. 1 Loose grill. 6 #6 Screws. 6 Wall Anchors. STEP BY STEP INSTALLATION INSTRUCTIONS Stepl. Place the metal sleeve (without the grill attached) against the wall with the flanged edge facing you. Trace the pipe on the outside with o pencil to mark the CUtOUt. (Refer to picture I) Step 2. Cut out the circular opening with a small drywall saw. Cut inside the pencil line. Take care not to damage the edge of the drywall since you will be installing drywall anchors close to the hole to mount the grill. (Refer to picture 2) Pic. 4 Pic. 5 ONE YEAR WARRANTY Pic. 6 Subject to the following limitations, Suncourt Inc. (manufacturer) warrants that the ThruWall FanTM will, for I (one) year from date of original retail purchase, but not exceeding two years from dote of manufacture, remain free from oppeoronce of defects in workmanship or materials. This warranty is subject to the following limitations: (o) manufacturer’s liability is limited to the replacement or repoir of the unit, as decided by the manufacturer; (b) o defective unit must be returned, prepaid, with proof of purchase, to the point of purchase or as instructe below; ond (c) this warranty does not apply to defects resulting from the alteration, abuse, accidental damage, unauthorized repair, or misuse of the unit. This warranty is given in lieu of all other warranties, guarantees, and conditions on manufacturer’s part, ond the manufacturer shall hove no tortious or other liability in respect to this ThruWall Fan SUNCOURT@ INC. 500 WEST SECOND AVENUE DURANT, IA 52747 1.800.999.3267 suncourt.com IWW108-0602
FREE ENGLISH PDF
USER GUIDE – USER MANUAL
OWNER GUIDE – OWNER MANUAL
REFERENCE GUIDE – REFERENCE MANUAL
INSTRUCTION GUIDE – INSTRUCTION MANUAL