Click here to download ATRIX OMEGA VACO22VDC (01) PDF MANUAL

PDF Content Summary:

****** Page 1 ****** ATRIX* TM OMEGA CORDLESS SERIES VACUUM INSTRUCTION MANUAL Model: VAC022VDC, PMP22VDC Atrix 1350 Larc Industrial Blvd. Burnsville, MN 55337 Telephone: 952.894.6154 Toll Free Telephone: 800.222.6154 Fax: 952.894.6256

****** Page 2 ****** Omega Cordless Series Vacuum Instruction Manual For Models: VAC022VDC, PMP22VDC IMPORTANT SAFETY INSTRUCTIONS Per CFR 49, Lithium Ion batteries may be considered “hazardous qoods.” As such, they are subiect to SPECIAL handlinq and/or packaqinq requlations for ground and air shipping. Proper shippinq procedures compliant with CFR 49 MUST BE FOLLOWED. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. When using your Vacuum, basic safety precautions should always be observed, including the following: AWARNING Vacuum Safety Read Owner’s Manual before using this product. Failure to do so can result in serious injury or death. Use only as described in this manual. Use only the recommended attachments, battery, charger, and replacement parts. DO NOT use the vacuum on wet surfaces. DO NOT expose to rain or water. DO NOT use or store vacuum in wet or moist conditions. DO NOT try to recover any liquid with this vacuum. This vacuum is for DRY RECOVERY only. DO NOT USE A DAMAGED VACUUM. If the unit is not working as it should, or if it has been damaged, left outdoors, or exposed to water, take it to an Authorized Repair Center for inspection and repair. DO NOT allow the vacuum to be used as a toy. Pay close attention when using the vacuum near children. DO NOT handle the switch or battery pack with wet hands. DO NOT put any objects into openings. Do not use with any opening blocked, keep free of dust, lint, hair, and anything that may reduce air flow. Keep hair, loose clothing, fingers, and all parts of body away from openings and moving parts. Use with extra care when cleaning on stairs. DO NOT vacuum flammable or combustible materials or anything that is burning or smoking, such as cigarettes, matches, or hot ashes. Sparks inside the motor can ignite flammable vapors, to reduce the risk of fire or explosion, do not use near combustible liquids, gases, or dusts, such as gasoline or other fuels, lighter fluid, cleaners, oil-based paints, or natural gas. To reduce the risk of inhaling toxic vapors or dust, DO NOT vacuum or use near toxic or hazardous materials. DO NOT use without filter in place. Remove battery pack before charging or servicing vacuum.

****** Page 3 ****** 1. 2. 3. 4. 5. 6. 7. 8. 9. THIS APPLIANCE IS INTENDED FOR COMMERCIAL USE ONLY. SERVICING, OTHER THAN NORMAL MAINTENANCE, MUST BE DONE BY AN AUTHORIZED SERVICE REPRESENTATIVE. VAC022VDC, PMP22VDC OPERATION INSTRUCTIONS Release the two front fasteners and open the lid. Remove hose and attachment from cover storage area. Remove the orange plug from the filter cartridge and store in unit. Slide one end of the super flex hose into the filter cartridge. Attach appropriate accessories on the hose assembly. Insert Battery into battery receptacle. Close lid and latch securely. Turn on the power switch. These vacuums have a factory installed resettable Thermal Cutout (TCO) for added operator and motor safety. If the unit gets too hot, the vacuum will shut down. Please check your hose and utensil for clogs or obstructions. In addition, it may be time to install a new filter. After checking all the above, please turn vacuum back on. FILTER CHANGE-OUT INSTRUCTIONS Your Omega Cordless includes a full filter indicator light underneath the on/off switch. This indicator is a guide to provide a visual of when it is time to consider removing the filter, disposing and inserting a new filter. Release the two front latches and open the lid. 1. Insert orange plug halfway in contaminated filter cartridge. 2. Lift the filter cartridge out by placing fingertips under lifting tabs located on the 3. ends of the cartridge and lift up. Push orange plug all the way in. 4. Dispose of the filter cartridge in an appropriate manner compliant with all local, 5. state, and federal laws. Insert new filter cartridge. 6. Close lid and latch securely. 7. Your Omega Cordless can be configured to allow its use in and around static sensitive devices by doing the following: 1. 2. 3. 4. Use *31671STUD hose. Attach *510-001-006 ground cord to hose. Attach other end of ground cord to a known ground or machine ground OR Attach the banana jack into the *SSISP-IOI Statguard and plug into 1 IOV wall outlet. Attach any ESD Safe Utensil to your hose.

****** Page 4 ****** VAC022VDC Descri tion Batte 22V PMP22VDC VACUUM REPLACEMENT PARTS Char er, 110V-240V, includes USA, Euro and UK cord Filter Hi h Efficienc Standard 0.3 micron retention Filter HEPA 99.97% Efficient at .3 micron Filter ULPA 99.999% Efficient at .12 micron Sam lin Filter, 6 Pack Su er Flex Hose ESD Safe 6′ Stretch Hose Toner- roof Su er Flex Hose ESD Safe 10′ Stretch Hose, Toner- roof Su er Flex Hose ESD Safe 16′ Stretch Hose, Toner- roof er Flex Hose w/10MM Stud ESD Safe 10′ Stretch *Groundin Cord for 31671STUD *Stat uard Ground Rece tacle Tester Clear NON STRETCH-NON ESD Safe Hose, 5’6″ Hose Plu Filter Plu Small Inlet Filter Plu Lar e Exhaust Gooseneck ESD Safe – Flexible, Desi ned to reach ti ht s Crevice Tool ESD Safe – Excellent for ti ht areas Crevice Tool NON-ESD Safe Crevice Tool Brush Non-ESD Safe, use with crevice tool Micro Attachment Kit ESD Safe Needle Nozzle ESD Safe Re lacement Latch Round Dustin Brush ESD Safe Round Dustin Brush Non-ESD Safe Shoulder Stra Utilit Nozzle Non-ESD Safe Utilit Nozzle Brush Non-ESD Safe Plastic Extension Wand, 20″ Non-ESD Safe Deluxe Back ack Deluxe Carr in Ba Ots Part No. VACOBAT VACOCHG 31700-1P OF612HE OF712UL SFU15/6 31661 31671 31681 31671STUD 510-001-006 SSISP-IOI AVPA008 AVPA005 410017 AVPA004 31657 31654 730030 31652 32555 32650 999500 31653 VAC31653 AVPA016 AVPAOII AVPA017 UE7022BK VACPACK 730060 Please contact Atrix for appropriate replacement parts: or e-mail: 1-800-222-6154

****** Page 5 ****** Battery and Charqinq Safety AWARNING To reduce the risk of electric shock, fire, battery explosion, or injury: Basic information and warning for ATRIX Battery and Charger are contained below. For detailed usage and warning information, read the HOW TO CHARGE THE BATTERY PACK carefully before using this unit. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. Use only the ATRIX Charger and ATRIX Battery Pack. DO NOT expose battery pack to temperatures above 1220F (500C). Never leave battery packs in automobiles on hot days, where temperatures can be much higher than the outside temperature. DO NOT use or store vacuum or batteries in wet or moist conditions, or with flammable or combustible materials. DO NOT charge batteries or store batteries for extended periods, 1 month or more, in temperatures above 900F (320C) or below 400F (50C). When charging, make sure that the charger has at least 6 inches of clearance on all sides. Adequate airflow is required to cool the charger when in use. DO NOT use a damaged cord or plug for charging. DO NOT pull on charger’s cord to unplug. Grasp and pull the plug, not the cord. DO NOT handle the charger’s cord plug with wet hands when inserting into electrical outlet. Keep sparks and flames away from batteries. Do not smoke near batteries or charger. DO NOT charge the unit outdoors. DO NOT attempt to repair, service, or modify the battery system or charger. Contact Atrix with any issues. DO NOT short-circuit the battery or charger terminals with conductive items such as paper clips. This can deliver high current, resulting in heat and fire. DO NOT crush, drop, incinerate or damage the battery pack. DO NOT use a battery pack that has been damaged in any way. DO NOT incinerate the battery even if it is severely damaged or non-working. The battery can explode in a fire. HOW TO CHARGE THE BATTERY PACK SPECIFICATIONS AND PARTS Charger Specification: Charger input: 100-240V 50/60Hz AC Charger output: 27V 4A Battery Specification: Lithium: 22V Watt hours: 95 Amp hours: 4.4 Approximate charge time: 1 hour Approximate run time: 30+ minutes Motor Specification: 190W Digital Brushless

****** Page 6 ****** OPERATION AWARNING Charge in well ventilated area. DO NOT block charger vents. Keep them clear to allow proper ventilation. CHARGING LITHIUM BATTERY PACKS It is not necessary to drain the battery pack completely before recharging. If the charger’s light is not lit at any point during the charging process, remove the battery pack from the charger to avoid damaging the product. DO NOT insert another battery. Contact Atrix with any issues. BATTERY PROTECTION FEATURE The 22-volt Lithium batteries are designed with features that protect the Lithium Polymer cells and maximize battery life. When the battery has reached its minimum voltage level the electronics will shut off the battery. Once the battery shuts off, it must be recharged. PREPARING BATTERY PACK FOR CHARGING BATTERY MUST BE REMOVED FROM VACUUM PRIOR TO CHARGING AND DURING CHARGING PROCESS. 1. Turn off the power switch. Push tab to UNLOCK the battery pack and REMOVE battery pack from the 2. vacuum. Plug the charger’s power cord into the charger. 3. Plug the round connector on the charger’s cord into the battery pack. 4. Plug the charger’s power cord into wall outlet. 5. 6. The indicator light will turn red when charging and turn Green when full charged. The Battery pack will require approximately 1 hour to full charge. Note: Battery pack and charger may get warm while charging.

****** Page 7 ****** Atrix 22V Omega Cordless Vacuum WARRANTY INFORMATION Warranty/Service Information, please contact Atrix International, Inc. Atrix 22V Omega Cordless Vacuums, Part no. VAC022VDC and PMP22VDC Limited Warranty: To the original user purchasing the Atrix 22V Omega Cordless Vacuum, Atrix warrants that the vacuum will be free of defects in material and manufacture for a period of one (1) year from the date of purchase. Should any failure to conform to this warranty appear within this period, contact Atrix. Per CFR 49, Lithium Ion batteries may be considered “hazardous qoods.” As such, they are subiect to SPECIAL handlinq and/or packaqinq requlations for ground and air shipping. Proper shippinq procedures compliant with CFR 49 MUST BE FOLLOWED. Exclusions to warranty coverage: The above warranty will not apply to any special configurations or to any units that have been modified, or damaged by negligence, misuse, accident or failure to follow Atrix’s Instruction Manual. Consumable supplies, such as filters and accessories are not covered by this warranty. Disclaimer of Warranty: EXCEPT FOR THE IMPLIED WARRANTIES OF TITLE AND AGAINST PATENT INFRINGEMENT, ATRIX MAKES NO OTHER WARRANTIES WITH RESPECT TO THE ATRIX 22V OMEGA CORDLESS VACUUM CLEANER, EXPRESS OR IMPLIED, INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. Limitation of Liability: ATRIX WILL NOT BE LIABLE UNDER ANY CIRCUMSTANCES FOR ANY COINCIDENTAL, SPECIAL, OR CONSEQUENTIAL DAMAGES OR ECONOMICAL LOSS, BASED UPON BREACH OF WARRANTY, BREACH OF CONTRACT, NEGLIGENCE, STRICT LIABILITY IN TORT OR ANY OTHER LEGAL THEORY, EVEN IF ATRIX HAS BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES INCLUDING, BUT NOT LIMITED TO LOSS OF PROFITS, REVENUE, EQUIPMENT USE, DATA OR INFORMATION OF ANY KIND. THE LIABILITY OF ATRIX SHALL NOT UNDER ANY CIRCUMSTANCE, EXCEPT AS EXPRESSLY PROVIDED HEREIN, EXCEED THE PRICE OF THE ATRIX 22V OMEGA CORDLESS VACUUM. To Register your Warranty Visit:








Leave a comment, question, review or page error below.

This site uses Akismet to reduce spam. Learn how your comment data is processed.